GOZNEY RBX1.1 Portable Pizza Oven
Safety Instruction
Fire
- Most fires are caused by a buildup of grease or, when using gas, an improper gas connection.
- Ensure all people and pets are kept as far away as possible.
- If you are able, turn the gas off at the cylinder or the on/off valve where applicable.
- Use a fire extinguisher if possible. If water is the only fire retardant available, thoroughly soak the area around the appliance.
- When spraying water on the Roccbox itself, do not use a strong jet of water, as this may cause splashing of burning grease, resulting in a further spreading of the fire.
Carbon Monoxide
- Carbon Monoxide is a highly poisonous gas which can be produced when the device isn’t receiving enough ventilation. We therefore recommend using the gas and wood burners in a well-ventilated area away from direct wind and to never cover the oven mouth.
- It is difficult to know if your device is producing Carbon Monoxide as it is an odourless and colourless gas. It can, however, cause these symptoms when you are exposed to it: Tightness across the forehead, Headache, Weakness, Dizziness, Nausea, Vomiting,
- Coma, intermittent convulsions, Depressed heart action, slowed respiration. If the exposure has been severe, it may cause death.
Product Information
| Gozney Group Ltd.Roccbox Limited.
Bobby’s, Third Floor, The Square, 2-12 Commercial Rd, Bournemouth, BH2 5LP.Units 18 & 19, Radar Way, Christchurch, Dorset, BH23 4FL UK. |
|||
| Appliance Name | Roccbox oven | ||
| Model/Type No. | RBX1.1 | ||
| Trade name | Roccbox | ||
| Total nominal heat output for the gas burner | 14330 BTU/HR | ||
| Injector size | 1.1mm | ||
| Gas Type | LPGPropane | Gas Pressure | 11 “W.C. |
Setting Up the Gas
Gas Safety
- Do not disconnect any gas fittings while the appliance is operating.
- Check all gas hose lines and connections for cuts, cracks and other damage.
- Gas cylinders must not be stored in enclosed areas.
- Keep the fuel supply hose away from heated surfaces or direct sunlight.
- Do not use any additional flammable substance whilst operating with gas.
- Do not touch! The Roccbox can get extremely hot when in operation. Be sure to wear protective gloves.
- Keep the cylinder outdoors in it’s upright position.
- Do not connect multiple gas canisters to Roccbox or store a spare within the same vicinity.
- A regulator which complies with EN16129 must fit between the gas canister and the oven.
- Do not position the gas canister under the oven.
- Never use a naked flame to check for gas leaks.
- Do not use natural gas! It can damage the oven.
- Maximum length of hose cannot exceed 1.5m. In Finland, hose length cannot exceed 1.2m.
- National requirements state how often to replace the hose. Please review this for your area.
- Never fill the cylinder beyond 80 percent full.
- Make sure the flexible tube is not twisting when the appliance is in operation.
- Do not put the pizza peel in the dishwasher.
Connecting To Gas
STEP 1 Check that the gas you have is Propane LPG.
The gas cylinder used must have a safety collar to protect the valve assembly. Do not use a cylinder that is rusty, dented or has a damaged valve. For US & Canadian Customers, Gas cylinder, must be constructed and marked in accordance with the specifications for LP gas cylinders, U.S. Department of Transportation (DOT) or the Standard for Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, CAN/CSA-B339.
Firing Up Gas
Connecting
STEP 2 Connect the regulator to the gas canister, following the instructions for your regulator accordingly. Don’t force the regulator as this could damage the gas bottle.
Clockwise Gas Regulator
Gas Leaks
To test for gas leaks, apply a mixture of soapy water to these highlighted areas using a brush as well as any areas that show cracks. on the piping.
Disconnecting Gas
After cooking, turn off the gas from the gas canister before turning off the Roccbox. This will allow any gas left in the burner or pipe to be used up safely.
First Firing
STEP 1
WARNING
Remove single-use carry strap before GOZNEY RBX1.1 Portable Pizza Oven using the oven.
STEP 2
Cleaning and Maintenance
We recommend cleaning and inspection of the gas GOZNEY RBX1.1 Portable Pizza Oven burner and included peel every time you use your oven. To do this simply detach the burner once it has cooled and use a brush and can of compressed air to clean it out. The peel should be hand cleaned with soapy water only, do not place the peel in the dishwasher. For general oven cleaning, all you have to do is wipe down the outside with some warm soapy water. The same goes for the burner as well, just empty it of any ash first.
Troubleshooting
If you think you’ve got a problem with your Roccbox, follow these troubleshooting pointers to sort the problem. For replacement parts and servicing contact Roccbox for further details. It is recommended to replace the gas hose every 5 years. Some countries may have different requirements, therefore you must adhere to their specified time period. Hose and regulators can be purchased from your nearest hardware store.
| Problem | Cause | Solution |
| Weak flame | • Empty/low gas cylinder
• High altitude • Cold gas cylinder |
• Try a different gas cylinder.
• Check gas regulator |
| Noisy burner | • Debris blocking head
• Debris in venturi |
• Clean burner. View Cleaning and maintenance section. |
| Slow heat up | • Empty gas cylinder
• Cold weather • Windy conditions |
• Try a different gas cylinder.
• Check gas regulator • Sheltered location |
FAQs
Q: What’s the cooking surface made of?
Ans: The floor of the RBX1.1 is made of cordierite stone, which evenly distributes and holds heat to create the texture of real pizza.
Q: Why is there smoke coming from the oven during use?
Ans: During early heating or when there is too much flour, a small amount of smoke is usual. Use a small amount of flour on your peel and make sure the oven is clean.
Q: Is the RBX1.1 really portable?
Ans: Indeed. With detachable parts for convenient storage and transportation, it is made to be small and foldable.
Q: Can I leave the oven outside in the rain?
Ans: No. It is not waterproof, but it is resistant to weather. When not in use, store it indoors or beneath a waterproof cover.
Q: Can I convert the oven to wood or charcoal?
Ans: With this model, no. The RBX1.1 is made exclusively to run on petrol. The warranty can be voided if you use other fuels.
Q: What if the ignition doesn’t spark?
Ans: Verify that the gas connection is tight, turn the control knob to ignition and check the battery (if any). Lighting can also be done by hand.
Q: Can I cook other food besides pizza?
Ans: Of course! Try steak, fish, roasted veggies, flatbreads, and even desserts made in cast-iron skillets.
Q: How do I measure the stone temperature?
Ans: Point an infrared thermometer at the stone’s centre. Pizza should be made between 400 and 500°C (750 and 932°F).